Volume 7, Issue 6, November 2019, Page: 270-276
The Change of Characteristics and Antioxidant Activity of Cocoa Vinegar During Fermentation of Pulp Liquids by Adding Tape Yeast
Gusti Putu Ganda-Putra, Department of Agroindustrial Technology, University of Udayana, Jalan Kampus Bukit Jimbaran, Badung, Indonesia
Ni Made Wartini, Department of Agroindustrial Technology, University of Udayana, Jalan Kampus Bukit Jimbaran, Badung, Indonesia
Received: Oct. 2, 2019;       Accepted: Oct. 21, 2019;       Published: Oct. 25, 2019
DOI: 10.11648/j.ajaf.20190706.14      View  32      Downloads  16
Abstract
The pulp liquids as a by-product of cocoa beans fermentation is potential to be used as a raw material for making cocoa vinegar, but unfortunately the content of acetic acid is relatively low and there have been no studies related to antioxidant activities. The objectives of the present study were to examine the effect of addition of tape yeast and fermentation time of pulp liquids to the changes of characteristics and antioxidant activities of cocoa vinegar and to define the best treatments of the addition of tape yeast and fermentation time for making cacao vinegar. The experiment in this study used factorial Group Randomized Design (GRD) with 2 factors. Factor I is the addition of tape yeast consisting of 5 levels, namely: without tape yeast (control), addition of 0.05; 0.10; 0.15 and 0.20% (w/v) and factor II is fermentation time which consists of 6 levels, namely: 5, 10, 15, 20, 25 and 30 days. The characteristics of cacao vinegar observed were as stated in SNI 01-437-1996, including: acetic acid, acidity (pH), total soluble solid (TSS), total sugar, and alcohol; and the antioxidant activity, namely: total phenolic and antioxidant capacity. The results showed that: (1) the changes in the characteristics of cocoa vinegar consisting of acetic acid content, acidity (pH), total soluble solids (TSS), total sugar content, and alcohol content; and the antioxidant activity based on the total phenolic content and antioxidant capacity occurred during fermentation with the addition of tape yeast, (2) the best treatment for making cocoa vinegar is the addition of 0.10% tape yeast and 25 days fermentation time, with its characteristics namely: 4.09±0.01% acetic acid content, acidity (pH) of 3.40±0.00, TSS of 5.05±0.07 (oBrix), 0.49±0.02% total sugar content, and 0.00% alcohol content; and antioxidant activities, namely: total phenolic content of 78.94±6.54 (mg/100g GAE) and antioxidant capacity of 12.50±0.14 (mg/L GAEAC).
Keywords
Cocoa Vinegar, Pulp Liquids, Tape Yeast, Quality Characteristics, Antioxidant Activities
To cite this article
Gusti Putu Ganda-Putra, Ni Made Wartini, The Change of Characteristics and Antioxidant Activity of Cocoa Vinegar During Fermentation of Pulp Liquids by Adding Tape Yeast, American Journal of Agriculture and Forestry. Vol. 7, No. 6, 2019, pp. 270-276. doi: 10.11648/j.ajaf.20190706.14
Copyright
Copyright © 2019 Authors retain the copyright of this article.
This article is an open access article distributed under the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0/) which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.
Reference
[1]
ICCO [Internet]. 2017. Top cocoa producing countries in the world. Available from: http://www.worldatlas.com/articles/top-10-cocoa-producing-countries.html.
[2]
Schwan RF, Wheals AE. 2004. The microbiology of cocoa fermentation and its role in chocolate quality. Critical Reviews in Food Science and Nutrition, 44 (4): 205-221.
[3]
Lopez AS. 1986. Chemical change occurring during the processing of cacao. Pennsylvania (US): Proceeding of The Cacao Biotechnology Symposium. Dept of Food Science College of Agricultutre, The Pennsylvania State University.
[4]
Ganda-Putra GP, Harijono, Susanto T, Kuamalaningsih S, Aulani’am 2008. Optimization of the condition of depolymerization of cocoa bean pulp by endogenous polyalgalactonase enzymes. Jurnal Teknik Industri, 9 (1): 24-34 (In Indonesian).
[5]
Ganda-Putra GP, Wartini NM. 2014. Quantity and characteristics study of liquid pulp as side results of cocoa bean fermentation using container system "thermos" for production of vinegar fermentation. Media Ilmiah Teknologi Pangan, 1 (1): 31-40 (In Indonesian).
[6]
Ganda-Putra GP, Wartini NM. 2016. The effect of addition of tape yeast during fermentation on characteristics of the watery sweatings byproduct of cocoa fermentation as raw material of vinegar. Agrotechno, 1 (1): 46-50 (In Indonesian).
[7]
Dias DR, Schwan RF, Freire ES, Serôdio RDS. 2007. Elaboration of a fruit wine from cocoa (Theobroma cacao L.) pulp. Int J Food Sci and Technol, 42 (3): 319–329.
[8]
Schwan RF. 1998. Cocoa fermentations conducted with a defined microbial cocktail inoculum. Applied of Environ Microbiology, 64 (4): 1477-1483.
[9]
Oddoye EOK, Agyente CK, Gyedu-Akoto E. 2013. Cocoa and its by-products: Identification and uttilization. Available from: https://www.researchgate.net/publication/302109658/ doi: 10.1007/978-1-61779-803-0_3.
[10]
Duarte, W. F., Dias, D. R., Oliveira, J. M., Teixeira, J. A., de Almeida e Silva, J. B., and Schwan, R. F. 2010. Characterization of different fruit wines made from cacao, cupuassu, gabiroba, jaboticaba and umbu. LWT— Food Science and Technology, 43 (10): 1564–1572.
[11]
Puerari C, Magalhães KT, Schwan RF. 2012. New cocoa pulp-based kefir beverages: Microbiological, chemical composition and sensory analysis. Food Research International, 48: 634–640.
[12]
Da-Silva EN, Da-Cruz Ramos D, Menezes LM, De-Souza AO, Da-Silva LSC, Da-Silva MV. 2014. Nutritional value and antioxidant capacity of “cocoa honey” (Theobroma cacao L.). Food Sci Technol, 34 (4): 755-759.
[13]
Johnston CS, Gaas CA. 2006. Vinegar: medicinal uses and antiglycemic effect. Medscape General Medicine, 8 (2): 61-70.
[14]
Adam MR. 1985. Vinegar in microbiology of fermented foods. 1st Ed. New York (US): Elsevier Applied Science Publishers. p. 147.
[15]
Lee BH. 1996. Fundamentals of food biotechnology. New York (US): VCH Publishers Inc.
[16]
Kunkee RE, Amerine MA. 1970. Yeast technology: yeasts in wine-making. In: Rose AH, J. S. Harrison JS, editors. The Yeasts. London (EN): Academic Press.
[17]
Ganda-Putra GP, Wartini NM, Damayanti LPT. 2017. Study on the method and time of pulp watery fermentation on the characteristics change of cocoa vinegar. AGRITECH, 37 (1): 38-47 (In Indonesian).
[18]
Steinkraus KH. 1983. Handbook of indegenous fermented foods. New York (US): Marcell Dekker Inc.
[19]
Tarigan J. 1988. Introduction to General Microbiology. Jakarta (ID): Directorate General of Higher Education, Ministry of Education and Culture, Republic of Indonesia (In Indonesian).
[20]
SNI 01-4371-1996. Indonesian national standard of fermented vinegar. Jakarta (ID): Indonesian National Standardization Council (In Indonesian).
[21]
Coseteng MY, Lee CY. 1987. Changes in apple polyphenolxidase and polyphenol concentrations in relation to degree of browning. J Food Sci, 52 (4): 985-989.
[22]
Burda S, Oleszek W. 2001. Antioxidant and antiradical activities of flavonoids. Jurnal of Agricultural and Food Chemistry, 49: 2774−2779.
[23]
Rahman A. 1992. Teknologi Fermentasi. Jakarta (ID): Penerbit Arcan.
[24]
Kozaki M, Lino H, Matsumoto T, Dizon EI, Rahayu K, Sanchez PC. 1998. Studies on the acid-producing bacteria of traditional vinegars from the Philippinnes and Indonesia. Yogyakarta (IND): Proc. Int. Conf. on Asian Network on Microbial Research, Gadjah Mada University. p. 451-464.
[25]
Ardhana MM, Fleet GH. 2003. The microbial ecology of cocoa bean fermentations in Indonesia. Int J Food Microbiol, 86: 87-99.
[26]
Reed G, Nagodawithana TW. 1991. Yeast Technology. New York (US): Van Nostrand Reinhold Publisher.
[27]
Datar RP, Shenkman RM, Cateni BG, Huhnke RL, Lewis RL. 2004. Fermentation of biomass-generated producer gas to ethanol. Biotechnology and Bioengineering, 86 (5): 587-594.
[28]
Daulay D, Rahman A. 1992. Fermented Vegetable and Fruit Technology. Bogor (ID): Inter-University Center for Food and Nutrition, Bogor Agricultural University (In Indonesian).
[29]
Anvoh KYB, Zoro-Bi A, Gnakri D. 2009. Production and characterization of juice from mucilage of cocoa beans and its transformation into marmalade. Pakistan J Nutrition, 8 (2): 129-133.
[30]
Li ZH, Wang Q, Ruan X, Pan CD, Jiang DA. 2010. Phenolic and plant allelopathy. Molecules, 15: 8933-8952.
[31]
Sing HP, Kohli RK, Batish DR. 2001. Allelopathy in agroeco systems: An overview. Journal of Crop Production, 4: 1-41.
[32]
Kubo IN, Masuoka P, Xiao PH, Haraguchi. 2002. Antioxidant activity of dodecyl gallate. J Agric Food Chem, 50: 3533-3539.
[33]
Suryanto E, Momuat LI. 2017. Correlation between antioxidant capacity and phenolic content of banana-corn composite flour. Proceedings: 2017 October 14; Yogyakarta (ID): National Seminar of Chemistry, Faculty of Mathematics and Natural Sciences, Yogyakarta State University. p. 189-200 (In Indonesian).
[34]
Kumalaningsih S. 2006. Natural Antioxidant. Surabaya (ID): Trubus Agrisarana. (In Indonesian).
Browse journals by subject